Immediately upon payment you will automatically be forwarded to our secure download page. Setting the Parking Brake 1. No single action on your part is as important as following the procedures for a proper break-in. Using a clean, dry cloth, clean the filter sealing surface on the crankcase. Refer to the gearcase specifications chart on page 70.
Customer Service 2006 Polaris Phoenix 200 Service Manual 214 Pages in. This warranty covers the parts and labor charges for repair or replacement of defective parts which are covered by this warranty. State of Voltage Charge 100% 12. Slow down before driving onto slippery surfaces. To make a turn, steer in the direction of the turn, leaning your upper body to the inside of the turn while supporting your weight on the outer footrest. Wash the pre-filter in soapy water, then rinse and let dry. Thanks 50cc to150cc Service Manual For Tank Motorsports.
All service must be performed by your authorized Polaris dealer. Avoid operating over large obstacles such as rocks and fallen trees when possible. When we discovered my mistake and corrected it, we turned on the bike, but the display did not light up and the key did not turn on the starter. Tons of pictures and diagrams at your fingertips!! Always replace the oil and filter within a few hours of draining the oil. Federal law requires that this spark arrestor be installed and functional when the vehicle is operated on public lands. All Manuals Are Windows and Mac compatible! Slide the boots 1 off the inline cable adjuster sleeve 2.
Start the engine and allow it to warm up, then shift the transmission into gear. What a cool way to find your problem and repair it on the trail, no down time on the job site, With our Repair Manual Downloads you instantly have access to the material needed to get you running again. A collision or rollover can occur quickly, even during routine maneuvers like turning, or driving on hills or over obstacles, if you fail to take proper precautions. Broke down on the trail or site and have a smart phone? Also any links to buy parts for this bike would help as it needs a new headlight assembly and some small cosmetic items. Be sure the fuel cap, oil cap and seat are installed correctly and securely. In a sentence, I reversed the positive and negative on the battery like a dummy. No more ruining your expensive paper shop manual with grease and dirt.
Loosen the adjuster locknut 3. Avoid hills with excessively slippery or loose surfaces. Beginners should receive training from a certified instructor. Once you download your manual it is yours forever. Camber and Caster The camber and caster are non-adjustable.
Apply the brakes lightly for stopping. Apply the brake with your right foot. Items not listed in the chart should be lubricated at the General Lubrication interval. Item Engine Oil Brakes Transmission Rear Gearcase. Use the same leaning technique for turning in reverse. Any condensation must be drained.
This is identical to squeezing the left brake lever on the handlebar. Always use Polaris-recommended spark plugs. Keep your feet on the footrests. Squeeze the left- -hand rear brake lever slightly to aid in slowing. See page 99 for the part numbers of Polaris products. I tried to be nifty by turning the battery to put the terminals in an easier spot to get to, but forgot to reverse the cables too. Fuel Valve The fuel valve 1 is located on the left side of the vehicle.
Turn the valve off before storage and when transporting. Using an oil filter wrench, turn the filter counterclockwise to remove. Always apply both brakes at the same time. Place shop towels beneath the oil filter. Has clickable chapters and is searchable so you can easily find what you're looking for. Avoid operating in water deeper than the bottom of the footrests 1.