Install the heater core to the heater module. D Disconnect the throttle cable 2. Install the brake pads and the cylinder assembly with the pin bolt. Install the blower motor cooling hose. D Inspect the rack and pinion boot for crack and wear 2. This rating is a measure of cold cranking ca- pacity. Here you will find — remove and install procedures, — technical specifications, — adjustment values, and — trouble shooting information Body Repair Manuals In case of repair works on sheet metal parts, this category holds important information.
Refer to Section 1F, Engine Controls. D Replace the wheels as needed. Remove the second gear synchronizer ring. Hang the front muffler to rubber hanger. Remove the air cleaner assembly. Maintenance manual Daewoo Matiz includes full information about assembly and disassembly, adjustment and setup of units and sets of motorbike Daewoo Matiz Model Year 2003.
D Remove the gear shift lever sensor connector. The normal value is about 13. A portion of the fluid also primes the pump. D The steering gear preload adjustment D Perform a rack bearing preload is out—of—adjustment. D Remove the tie rod lock nut 2. D Remove the shift lever plate 3.
Most premium noted in Failure Records or Freeze Frame data. Remove the steering knuckle assembly. Install the front bumper fascia. Perform the diagnostic system check. Are all checks and repairs complete? D Cover the rotor with the cloth 1. D Loosen the upper radiator hose clamp and discon- nect the upper radiator hose 1.
D Disconnect the connector 2. Install the brake shoe components. Wait 1 to 2 minutes. Is the long term fuel trim reading within the value specified? Evacuarea aerului din sistemul de franare. D Tighten to the specified torque. After the vehicle is brought into a warm shop for 80°C 176°F. Perform the diagnostic system check.
With the engine sufficiently cool, remove the — surge tank cap. Does the scan tool indicate that this diagnostic ran and passed? Are all checks and needed repairs complete? D105A701 D Remove the spring 3. Install the brake hose coupling bolt 2. Front Disc Brake Hose 16. It also has the Child Safety Locks which makes sure that the little ones are always safe at the back. D Remove the gasket 6.
It comes with a 1. Remove the defroster duct and hoses. It has been available solely as a five-door hatchback. D Disconnect the electrical connector 3. D Remove the bleeder plug cap 2.
D Remove the coolant pump 3. D Tighten the adjuster plug softly 3. D Remove the shock damper ring 5. The dump cartridges are operated independently to control the deceleration of the wheel. Install the fourth synchronizer ring and wave spring. D Place the rack gear in the straight-ahead position. Install the cable pulley with the adjustment nuts.